Which Generac Generators Were Recalled in 2026?
On April 16, 2026, the U.S. Consumer Product Safety Commission recalled approximately 149,400 Generac portable generators due to a carburetor defect that can cause fuel to leak during initial fueling, creating a fire and burn hazard. The recall covers models in the GP3600, GP4000DF, GP6500, GP6500E, GP6500CO, GP6500EDF, GP6700EDF, GP8000E, GP9200E, and GP9500ETF families sold between May 2025 and February 2026 at major retailers including Home Depot and Lowe’s. Generac received 114 reports of fuel leaks before the recall was issued, and the CPSC classified the defect as posing a risk of serious injury or death.
What is wrong: A carburetor defect can cause fuel to leak when the generator is first filled with gasoline, creating a fire and burn hazard near the engine and fuel system.
What to do: Stop using a recalled generator immediately and visit generac.com/about/recalls/GP-Carburetor to check your model and serial number. Generac is offering a free dealer repair.
Storm season urgency: Florida’s hurricane season runs through November 30. If your generator is one of the 149,400 recalled units and you have not had it repaired, it is not safe to use during a power outage.
Full List of Recalled Models
The April 2026 recall covers specific serial number ranges within the following model families. All recalled generators feature an orange and black design with a steel-tube cradle frame.
| Model Family | Model Number(s) | Sold Between |
|---|---|---|
| GP3600 | G0081320 | May 2025 to Feb 2026 |
| GP4000DF | G0081420 | May 2025 to Feb 2026 |
| GP6500 | G0076802 | May 2025 to Feb 2026 |
| GP6500E | G0076812 | May 2025 to Feb 2026 |
| GP6500CO | G0081560 | May 2025 to Feb 2026 |
| GP6500EDF | G0081530 | May 2025 to Feb 2026 |
| GP6700EDF | G0080620 | May 2025 to Feb 2026 |
| GP8000E | G0077150 | May 2025 to Feb 2026 |
| GP9200E | G0081470 | May 2025 to Feb 2026 |
| GP9500ETF | G0081570 | May 2025 to Feb 2026 |
Not every unit within these model numbers is recalled. The recall applies to specific serial number ranges within each model. You must enter your model and serial number at the Generac recall checker page to confirm whether your specific unit is included. The model number and serial number are printed on a label on the generator frame.
This recall does not cover Generac home standby generators, inverter generators, or any portable generator models not listed above. If your generator is a Generac home standby unit (the permanently installed type connected to your electrical panel), it is not part of this recall.
What Is the Fire Risk With Recalled Generac Generators?
The defect is in the carburetor. When a recalled generator is filled with gasoline for the first time, fuel can leak from the carburetor area. Gasoline leaking near a hot engine, near electrical connections, or near any ignition source creates an immediate fire and burn hazard.
The CPSC received 114 reports of fuel leaks before issuing the recall. No injuries had been confirmed at the time of the announcement, but the CPSC classified the risk as serious injury or death, which is the highest hazard classification.
In Central Florida, this risk is especially relevant because portable generators are most commonly used during hurricane-related power outages, often in rain, wind, and darkness, all conditions where a fuel leak is harder to detect and more dangerous to manage. A homeowner pulling a recalled generator out of the garage after a storm hits does not have the luxury of a calm, well-lit inspection. The repair needs to happen before the storm, not during it.
How to Check Your Generator and Get the Free Repair
Follow these five steps to determine whether your Generac portable generator is part of the recall and to arrange the repair.
- Locate your model and serial number. The model number and serial number are on a label attached to the generator frame. Write them down or take a photo.
- Visit the Generac recall checker. Go to generac.com/about/recalls/GP-Carburetor and enter your model and serial number. The checker will tell you whether your specific unit is included in the recall.
- If your generator is recalled, stop using it immediately. Do not fill it with gasoline and do not start it until the repair has been completed by an authorized Generac dealer.
- Contact an authorized Generac dealer to schedule the free repair. Generac is covering the cost of the carburetor repair at no charge. You can also call Generac at 888-391-0503, Monday through Friday, 8 a.m. to 5 p.m. CT.
- If you have already fueled and used the generator without a leak, you may continue using it. The CPSC states that consumers whose generators have already been filled with enough gasoline to move the fuel gauge off empty, and who have not experienced any fuel leakage, may continue to use the generator. However, arranging the free repair is still recommended.
If you are relying on a portable generator for hurricane season backup power in Central Florida, now is the time to check the recall status and make sure your electrical system is ready for an extended outage. Super Fast Electric handles generator hookups, transfer switch installations, and whole-house electrical inspections across Orange, Seminole, and Osceola counties.
Generator Safety Beyond the Recall
Even if your generator is not part of the 2026 recall, portable generators create carbon monoxide, electrical, and fire hazards that kill people in Florida every hurricane season. The CPSC reports that portable generators are associated with roughly 70 carbon monoxide deaths per year nationally, with post-hurricane use accounting for a significant share.
Follow these safety rules every time you run a portable generator:
- Operate the generator outdoors only, at least 20 feet from the house, with the exhaust directed away from windows, doors, and vents. Never run a generator in a garage, carport, or enclosed patio, even with the door open.
- Never connect a generator directly to your home’s wiring. Plugging a generator into a wall outlet (backfeeding) sends power back through the panel and out to the utility lines, which can electrocute utility workers restoring power and destroy your generator when the grid comes back on.
- Use a transfer switch. A transfer switch is an electrical device installed at your panel that safely connects the generator to your home’s circuits and isolates them from the utility grid. It is the only safe, code-compliant way to power your home’s wiring from a portable or standby generator. If your home does not have a transfer switch, a licensed electrician can install one, typically in half a day.
- Keep fuel stored safely. Store gasoline in approved containers, away from the generator and away from the house. Never refuel a running or hot generator.
- Install carbon monoxide detectors. Battery-operated CO detectors on every level of the home are the last line of defense against generator exhaust infiltration during a storm.
We install transfer switches and generator hookups across the Orlando metro area, and the one thing we see every hurricane season is homeowners who wait until the storm is in the forecast to find out their generator setup is not safe. A transfer switch installation takes about four to six hours in most homes, and it needs to happen before the storm. For a full look at what we offer, visit our electrical services page.
Previous Generac Recalls to Check
The April 2026 recall is not the first Generac portable generator recall. If you own an older Generac unit, check whether it was covered by a previous action.
2023: GP15000E and GP17500E recall. Generac recalled these large portable generators due to a fire and burn hazard from a fuel leak at the fuel line connection. Different models, different defect, separate from the 2026 action.
2021: GP6500 and GP8000E recall. An earlier recall covered different serial ranges of the GP6500 and GP8000E for a finger amputation and crush hazard related to the locking mechanism on the handle. Different hazard, different models.
Each recall is a separate action with its own model numbers, serial number ranges, and repair procedure. If you own multiple Generac generators, check each one individually against each recall notice.
Frequently Asked Questions
How do I check if my Generac generator is recalled?
Visit generac.com/about/recalls/GP-Carburetor and enter your model and serial number. The model and serial number are on a label on the generator frame. The checker will confirm whether your specific unit is included in the April 2026 recall. You can also call Generac at 888-391-0503.
Can I still use my recalled Generac generator?
If your generator has already been filled with gasoline and you have not experienced any fuel leakage, the CPSC says you may continue using it. If the generator has not yet been fueled or if you noticed leaking during fueling, stop using it immediately and arrange the free repair through an authorized dealer.
Are Generac home standby generators part of the recall?
No. The April 2026 recall covers only portable GP-series generators. Generac home standby generators, which are permanently installed and connected to your electrical panel, are not part of this recall.
How much does the recall repair cost?
Nothing. Generac is providing the carburetor repair at no charge through authorized dealers. Contact your nearest Generac dealer or call the recall hotline to schedule the repair before hurricane season.
Can I get a refund instead of a repair?
As of October 2026, Generac is offering a free repair only, not a refund or replacement. A class action lawsuit filed in May 2026 is seeking additional remedies, but the current recall program provides the dealer repair at no cost.
Do I need a transfer switch for my portable generator?
Yes, if you want to power your home’s built-in circuits safely. Plugging a generator into a wall outlet (backfeeding) is illegal, violates the National Electrical Code, and can electrocute utility workers. A transfer switch installed at your electrical panel is the only safe and code-compliant connection method.
Next Steps
Check your Generac portable generator model and serial number against the recall list at generac.com/about/recalls/GP-Carburetor.
If your generator is recalled, stop using it and arrange the free dealer repair before storm season.
If your home does not have a transfer switch, schedule a transfer switch installation before the next storm enters the forecast.
Need a generator hookup, transfer switch, or whole-house electrical inspection? Get a quote from a licensed Orlando electrician who handles storm prep every season.
A recalled generator in the garage is not a backup plan. Neither is a working generator without a transfer switch. Super Fast Electric handles transfer switch installations, generator hookups, and storm-prep electrical inspections across Orange, Seminole, and Osceola counties. Licensed, insured, and ready before the next storm. Get a quote today.
